College Interview Tips For Advanced

Deadly mistakes to write characters

The industry lets out pasta of the following grades: from a flour of a krupchatka - a grade extra and extra egg with addition on 1t a flour 100 - 152 kg of melange; from a premium flour - the highest (without additions), the highest egg with addition of melange or eggs, the highest dairy with addition of powdered whole or skim milk (5-10% of weight of a flour), the highest tomato with addition on 100 kg of a flour of 15 kg of a tomato - paste (the maintenance of 40% dry and the highest for baby food with addition on 100 kg of a flour of 400 pieces of eggs and 3,5 kg of powdered milk; from a flour of the 1st grade - the first (without additions), the first tomato, the first dairy and the first for baby food.

- flour dust; movement of a flour on materialoprovoda (pipes on which the flour by means of aspiration (a blowing method) arrives is followed by allocation of a flour in air which gets into an air duct of an aspiration network and goes to a cyclone. However sometimes it is not enough air in a cyclone and exceeds its emissions in environment MPE (maximum permissible emissions), (according to SN-1042-7Z) 0,5 g/sec. are equal;

Indicators of quality of pasta are: appearance, taste and a smell, existence of broken lines, the deformed products, and also crumbs, humidity of products, their acidity, a razvarivayemost, durability absence in them granary wreckers and metalimpurity.

When using a wheaten gluten the content of albumens in products can increase by 30 - 40%. The gluten is withdrawal by production of wheat starch and its use as the dresser economically expediently.

Humidity of products should not exceed 13% (in products for baby food of 12%). For the pasta sent to the remote areas (Far North, Sakhalin, etc.), moisture content has to be no more than 11%. Acidity of products has to be no more than 3,5-4 . The increased acidity of products arises at violation of the mode of drying, use of a substandard flour.

Cooling of the dried-up products. This process is necessary to level high temperature of products with air of packing office. If to pack pasta without cooling, evaporation of moisture to proceed already in packing that will lead to reduction of mass of the packed products.

Pasta contains (in %): waters-13; proteins - 10,4-11,8; fat - 0,9-2,7; carbohydrates 72,2 - 75,2; celluloses – 0,1-0,2; vitamins B, RR. Power value 100g. macaroni of-332-341 kcal, or 1389-1427 kJ.

Main type of concentrating additives are proteinaceous dressers to whom fresh eggs, yaytseprodukta (melange, egg powder), a gluten of wheat flour, casein, whole and powdered milk, whey, etc. concern.

It is historically proved that the homeland of pasta is Italy. In the Middle Ages the pressing devices were put in action by means of horsepower or on water-mills, and at emergence of the first cars there were steam units.

Vpressovyvayemy products before sharp or in time are sharp intensively blow air for receiving on their of the dried crust. It prevents crude products to drying surfaces and adhesion of among themselves during drying.

Proteins of pasta are acquired for 85%, fats for 93%, carbohydrates for 96%. Among mineral substances there is a lot of phosphorus, potassium, sodium, but it is not enough calcium, also pasta contains insufficient amount of such not replaceable amino acids as a lysine, methionine,.

Weight and packing products have to be packed into transport container: boxes wooden, boxes board, from corrugated fibreboard, boxes from a wattled interline interval and from a cast cardboard with a net weight no more than 30 kg, are covered inside by a white brown paper which upper edges are bent so that the ends would block it each other.